Toyota 4 Runner/Hilux/Surf

1987-1998 of release

Repair and operation of the car

Toyota 4ranner
+ 1. Maintenance instruction
- 2. Maintenance
   2.1. Specifications
   2.2. Arrangement of knots and units
   + 2.3. Frequency of maintenance and types of procedural works
   2.4. Intensive service
   - 2.5. Check of level of liquids
      2.5.1. Check of level of oil
      2.5.2. Cooling liquid
      2.5.3. Liquid in a windscreen washer tank
      2.5.4. Restoration of level of electrolyte
      2.5.5. Liquid in a hydraulic actuator of coupling and brakes
   2.6. Check of tires
   2.7. Check of level of liquid in automatic transmission
   2.8. Liquid level in system of a hydraulic actuator of a steering
   2.9. Replacement of oil in the engine and an oil filter
   2.10. Care of the battery
   2.11. Check of the cooling system
   2.12. Check of a condition of the hoses located in a motor compartment
   2.13. Screen wiper brushes
   2.14. Shift of wheels
   2.15. Check of a suspension bracket of a steering
   2.16. Greasing of a running gear, suspension brackets, steering and details of a body
   2.17. Check of an exhaust system
   2.18. Check of level of oil in a manual transmission
   2.19. Check of level of oil in a transfer case
   2.20. Check of level of oil in a reducer
   2.21. Check of seat belts
   2.22. Check of covers of half shafts
   2.23. Zolotnik of ventilation of a case
   2.24. The filtering element of the air filter
   2.25. Belts of the drive of hinged units
   2.26. Check of fuel system
   2.27. Check of wear of brakes
   2.28. Check and adjustment of pedals of coupling (brake)
   2.29. Replacement of candles
   2.30. Check and adjustment of gaps in valves
   2.31. Replacement of the fuel filter
   2.32. High-voltage wires, runner and cover of the distributor
   2.33. Care of the cooling system
   2.34. Naves and bearings of forward wheels
   2.35. Replacement of liquid in automatic transmission and the filter
   + 2.36. Oil replacement
   2.37. Check of a tank with an absorber
   2.38. Valve check of system of recirculation
+ 3. Engines
+ 4. Systems of heating, ventilation
+ 5. Fuel and exhaust systems
+ 6. Transmissions
+ 7. Transmission elements
+ 8. Brake system
+ 9. Suspension bracket and steering
+ 10. Body
+ 11. Electric equipment
+ 12. Electroschemes

2.5.2. Cooling liquid

Check of level

1. All cars considered in this manual are equipped with the cooling system under pressure. The broad tank (it is specified by an arrow) is near a radiator.
2. Liquid level in a broad tank depends on engine temperature. On the cold engine the level of liquid needs to be brought to level slightly above Low tank mark, on heated-up – to Full mark for what turn off a stopper of a broad tank. The recommended structure and brand of liquid are specified in the maintenance instruction of the car.
3. Need of a frequent dolivka of liquid indicates existence of a leak in system and need of elimination of its reason. Check survey a condition of a radiator, and all hoses. If visually traces of a leak it is not revealed, it is necessary to carry out pressure testing of all cooling system and check of a stopper of a radiator. Tests by method of pressure testing will help to find even insignificant, earlier imperceptible leak. Upon termination of wrap a stopper of a broad tank.
4. At detection of strong pollution replace liquid with a rust.
5. If necessary to turn off a stopper of a radiator wind it with rags and turn to the first emphasis, then having waited a little, get a stopper.
6. Do not allow hit of antifreeze on the painted surface.