Toyota 4 Runner/Hilux/Surf

1987-1998 of release

Repair and operation of the car

Toyota 4ranner
+ 1. Maintenance instruction
+ 2. Maintenance
+ 3. Engines
+ 4. Systems of heating, ventilation
+ 5. Fuel and exhaust systems
+ 6. Transmissions
+ 7. Transmission elements
+ 8. Brake system
+ 9. Suspension bracket and steering
+ 10. Body
- 11. Electric equipment
   11.1. Specifications
   11.2. Battery
   + 11.3. System of ignition
   11.4. Ignition coil(s)
   11.5. Ignition distributor
   11.6. Check and installation of the moment of ignition
   11.7. Block of electronic ignition
   11.8. Induction sensor
   + 11.9. System of a charge of the battery
   + 11.10. Generator
   11.11. System of start-up of the engine
   + 11.12. Starter electric motor
   11.13. Traction relay
   11.14. Check of tension
   11.15. Detection of short circuit
   11.16. Check of reliability of grounding
   11.17. Check of integrity of a chain
   11.18. Finding of not closed chain
   11.19. Search of malfunctions
   11.20. Safety locks
   11.21. Fusible crossing points
   11.22. Breakers
   11.23. Relay
   11.24. Breaker of indexes of turn / alarm system
   11.25. Switch of indexes of turn
   11.26. Lock of ignition and drum of the lock
   11.27. Switch of external lighting
   11.28. Screen wiper switch
   11.29. Lamps of headlights
   11.30. Adjustment of headlights
   11.31. Headlight case
   11.32. Replacement of lamps
   11.33. Receiver and loudspeakers
   11.34. Antenna
   + 11.35. Screen wiper electric motor
   11.36. Switch of heating of back glass
   11.37. Heater of back glass
   11.38. Guard of devices
   11.39. Sound signal
   11.40. Electric drive of mirrors
   11.41. Cruise control
   + 11.42. Window regulator electric drive
   11.43. Electric drive of door locks
   11.44. Safety cushions
+ 12. Electroschemes

11.23. Relay

GENERAL INFORMATION

Relays are used to the operated inclusion and shutdown of the silnotochny consumer under the influence of an electric signal of low power. On the considered cars of the relay are included in chains of such consumers as units of fuel system, a starter, fog lights.

Relays are mounted in the uniform block located in a motor compartment, and also in various parts of the car. The relay can be got and checked, the faulty relay changes.

Check

PERFORMANCE ORDER

1. The most reliable results are yielded by check with use of the scheme of turning on of the relay. If the scheme of inclusion is absent, execute checks taking into account the following data.

2. Couple of conclusions of any relay is connected to the coil providing operation of the relay. Other conclusions become in pairs isolated or disconnected at a coil zapityvaniye.

3. As a rule, distributing of contacts is specified on the relay case.

4. Connect one of relay coil conclusions to a positive conclusion of the battery through a wire with a thin delay as a safety lock. Connect the second conclusion to weight. After connection click has to be listened. If click is not present, change polarity of connection (polarity of connection matters on some relays).

5. Check existence of a chain between relay conclusions according to marking on the case.

6. If results of checks negative, replace with the relay.